AUDI A4 Avant IV
FSI,
2008-2012
2010
2011
2012
2013
2014
2015
2016
2017
2018
2019
2000
2001
2002
2003
2004
2005
2006
2007
2008
2009
1990
1991
1992
1993
1994
1995
1996
1997
1998
1999
1980
1981
1982
1983
1984
1985
1986
1987
1988
1989
AUDI
Autod
Kaubavedu
Mootorrattad
ALFA ROMEO
AUDI
BMW
CADILLAC
CHEVROLET
CHRYSLER
CITROËN
DACIA
DAEWOO
DAF
DAIHATSU
DODGE
FIAT
FORD
GAZ
GMC
GREAT WALL
HONDA
HUMMER
HYUNDAI
INFINITI
ISUZU
IVECO
JAGUAR
JEEP
KIA
LADA
LAND ROVER
LEXUS
MAZDA
MERCEDES-BENZ
MG
MINI
MITSUBISHI
NISSAN
OPEL
PEUGEOT
PONTIAC
PORSCHE
RENAULT
RENAULT TRUCKS
ROVER
SAAB
SEAT
SKODA
SMART
SSANGYONG
SUBARU
SUZUKI
TESLA
TOYOTA
VOLVO
VW
ZAZ
A4 Avant IV
FSI

AUDI A4 Avant IV, Estate, 08-12, CALA

AUDI A4 Avant IV, Estate, 08-12, CALA

General data
General basic values :
92,80 Stroke
Timing chain Type of engine control
84,50 Bore
4 Valves per cylinder
Hydraulic tappets Compensation for valve play
6 Number of spark plugs/glow plugs required
1-4-3-6-2-5 Firing sequence
10,00 - 14,00 Compression pressure (Difference max. 3 bar ) [new engine ]
12,00 Compression ratio
0,050 Maximum deformation of cylinder head
139,20 Minimum cylinder head height
2,50 Minimum engine oil pressure when idling (Test temperature 80° C )
Cooling system :
1,40 - 1,60 Cooling system pressure (radiator cap opening pressure)
87° - 102° Thermostat opens at temperature
Fuel system
Fuel system in general :
OTTO 91 ROZ Type of fuel (Loss in power ) [Alternative possibility: ]
Direct injection Mixture processing designation
3,00 - 6,00 System pressure (in front of high-pressure pump ) [Low-pressure side ]
Exhaust gas test values
General exhaust-gas-relevant values :
600 - 800 Idling speed with manual gearbox
600 - 800 Idling speed with automatic gearbox
80 Minimum engine oil temperature at VET
Petrol exhaust gas values :
0,00 - 0,50 CO content at idling
2500 - 3000 Increased idling speed
0,00 - 0,20 CO content at increased idling
120 Petrol conditioning time
2500 - 3000 Petrol conditioning speed
wideband sensor Lambda sensor design
600 - 800 Test speed for lambda sensor signal
0,97 - 1,03 Lambda value
Chassis data
Chassis settings :
0°20'+0°10'-0°10' Toe-in rear
-1°20'+0°25'-0°25' Camber rear (maximum difference between left and right 0°30' )
Vehicle ready for operation with spare wheel, tools, accessories and full tank. Conditions for axle measurement
0°20'+0°14'-0°14' Toe-in front (total toe) [Test value ]
20°00'+0°00'-0°00' Wheel steering angle inner wheel (relative steering angle)
18°11'+0°30'-0°30' Wheel steering angle outer wheel (relative steering angle)
Wheel rims and tyres :
0,00 Rear tyre pressure (see sticker on the inside of the driver's door )
0,00 Front tyre pressure (see sticker on the inside of the driver's door )
Chassis dimensions :
2808 Wheel base
1564 Tread front
1551 Tread rear
Brake system
Brake dimensions :
18,80 Front axle brake lining thickness [with backing plate, PR. - number 1LJ ]
7,00 Front axle brake lining thickness wear limit [with backing plate ]
345,00 Front axle brake disc diameter [PR. - number 1LJ ]
30,00 Front axle brake disc thickness [PR. - number 1LJ ]
28,00 Front axle brake disc thickness wear limit [PR. - number 1LJ ]
57,00 Front axle brake piston diameter
17,50 Rear axle brake lining thickness [with backing plate ]
7,00 Rear axle brake lining thickness wear limit [with backing plate ]
330,00 Rear axle brake disc diameter [PR. - number 1KE ]
22,00 Rear axle brake disc thickness [PR. - number 1KE ]
20,00 Rear axle brake disc thickness wear limit [PR. - number 1KE ]
43,00 Rear axle brake piston diameter
Engine tightening torques
Auxiliary assemblies :
20 Nm Air-conditioning compressor holder
25 Nm Air-conditioning compressor
23 Nm Alternator
40 Nm Accessory drive belt deflection pulley
40 Nm Accessory drive belt tensioning device
9 Nm Vacuum pump
22 Nm Servo pump pulley
20 Nm Servo steering pump
9 Nm Hydraulic line(s) at servo-steering pump [M6, Screw(s) ]
Start system :
65 Nm Starter [M10 ]
Engine management :
55 Nm Lambda sensor
9 Nm Crankshaft sensor
20 Nm Knock sensor
9 Nm Camshaft sensor
Engine mounting :
40 Nm Engine bracket [on the engine block ]
90 Nm + 135° Subframe diagonal strut(s) (Use new screws. ) [M12 x 42 ]
Engine block :
30 Nm + 90° Connecting rod bearing (Use new screw(s). )
20 Nm + 90° Crankshaft pulley (Use new screw(s). )
60 Nm Flywheel (Use new screw(s). ) [to drive plate ]
60 Nm + 90° Drive plate (Use new screw(s). ) [on crankshaft ]
23 Nm Main bearing [Screw(s) 17 - 31 ]
60 Nm Balance shaft gear wheel [Central bolt ]
Cooling system :
9 Nm Coolant pump
20 Nm Coolant pump pulley
Fuel supply :
25 Nm Fuel line [High-pressure side ]
Carburetion :
20 Nm Injection pump (Tighten bolts uniformly in several passes. ) [High-pressure pump ]
9 Nm Fuel-distributing pipe
27 Nm High-pressure line
9 Nm High-pressure pump
Exhaust system :
23 Nm Catalytic converter (Replace nut. )
25 Nm Exhaust manifold [02 stage ]
Engine control :
5 Nm + 90° Timing case cover 2. cylinder row (Use new screw(s). )
5 Nm + 90° Timing case cover 1. cylinder row (Use new screw(s). )
16 Nm Timing case cover [Screw(s) 4, 05 stage ]
80 Nm + 90° Outlet camshaft wheel (Use new screw. )
80 Nm + 90° Inlet camshaft wheel (Use new screw. )
8 Nm + 45° Control drive sprocket wheel (Use new screw(s). ) [Bearing pedestal ]
9 Nm Camshaft timing chain tensioner
9 Nm Control drive chain tensioner
10 Nm + 90° Control drive timing chain slip rail (Use new screw(s). )
10 Nm + 45° Drive chain – balance shaft chain tensioner (Use new screw(s). )
10 Nm + 45° Oil pump drive chain tensioner (Use new screw(s). )
5 Nm + 90° Top part of control unit housing (Can replace bolt(s). )
Cylinder head :
8 Nm + 90° Camshaft bearing [02 stage ]
9 Nm Valve cover (set)
9 Nm Cylinder head screws [Screw(s) 9, 07 stage ]
Engine lubrication :
30 Nm + 90° Oil pump chain wheel (Use new screw. )
5 Nm + 90° Oil sump (Use new screw(s). ) [Oil sump lower part ]
30 Nm Oil drain plug(s)
20 Nm Oil pump
9 Nm Oil cooler
13 Nm Oil filter housing [on the engine block ]
Ignition system :
30 Nm Spark plugs
Air intake system :
8 Nm Intake manifold [Upper section of intake manifold ]
Power transmission tightening torques
Gearbox mounting :
40 Nm Gearbox support [At the gearbox ]
20 Nm Gearbox mounting [at the crossmember, Nut(s) ]
70 Nm Gearbox support
Gearbox lubrication :
30 Nm Oil control screw(s) (Use new seal and screws. ) [Multitronic 0AW ]
5 Nm + 90° Gearbox oil filter cover (Use new screw(s). ) [Multitronic 0AW ]
45 Nm Gearbox oil filler plug (Oil control screw(s) ) [with 6-speed gearbox ]
35 Nm Distributor gearbox oil control screw (Use new seal and screws. ) [with automatic gearbox, 6 gear 0B6 ]
Differential :
30 Nm Differential oil control screw [Multitronic 0AW ]
Gearbox :
30 Nm + 90° Gearbox flange connection at engine (Reuse screws only 1 times. ) [M12 x 125 ]
Clutch :
22 Nm + 90° Clutch pressure plate (Use new screws. )
60 Nm Clutch module (Tighten screw(s) one after the other using prescribed torque. ) [03 stage ]
20 Nm Clutch slave cylinder
5,5 Nm Clutch slave cylinder bleeder valve [Gearbox 0B2 ]
Axle drive :
24 Nm Propeller shaft heat protection plate
30 Nm + 90° Propeller shaft(s) (Start with the screw at the color dot, use new screw. )
23 Nm Drive shaft heat protection plate
Gear shifting :
20 Nm Gear rod (Use new nut(s). )
Suspension front tightening torques
Front axle wheel suspension :
7 Nm Front suspension cross-brace [Screw(s) ]
140 Nm Front axle support joint at transverse control arm [Nut with washer assembly(ies), M14, Code range 21 mm ]
40 Nm Front axle support joint at stub axle (Use new screw(s). )
40 Nm + 90° Front axle stabiliser support at stabiliser (Use new screw(s). )
40 Nm + 90° Front axle stabiliser support at suspension strut (Use new screw(s). )
25 Nm Front axle stabilizer mount at subframe (Use new nut(s). )
70 Nm + 180° Lower front front axle transverse control arm (Use new screw(s) and nut(s). ) [at subframe ]
Front axle brake :
196 Nm Front axle brake caliper mounting support (Use new screw(s). ) [PR. - number 1LJ ]
5 Nm Front axle brake disc
9 Nm Wheel speed sensor
16 Nm Brake line [M14 ]
20 Nm Brake hose [at the brake caliper, PR. - number 1LA ]
15 Nm Bleed valve [PR. - number 1LJ ]
Front axle steering :
20 Nm Pressure line at steering gear [with hydraulic servo-steering ]
20 Nm Return line to steering gear [with hydraulic servo-steering ]
60 Nm Track rod end on track rod
110 Nm Track rod end on stub axle [Nut with washer assembly(ies), Hexagon ]
100 Nm Track rod on steering gear [with electric servo-steering ]
30 Nm + 90° Lower steering column joint (Use new screw(s). )
80 Nm + 180° Steering gear (Use new screw(s). ) [at subframe ]
Wheels/tires :
4 Nm Tyre pressure sensor(s)
Front axle suspension :
40 Nm + 90° Front axle suspension strut bearing pedestal (Use new screw(s). ) [on chassis ]
Suspension rear tightening torques
Rear axle steering :
90 Nm + 90° Rear axle track rod (Use new screw(s) and nut(s). ) [on stub axle ]
Rear axle wheel suspension :
120 Nm + 360° Track control arm, rear axle, lower (Use new screw(s) and nut(s). ) [on stub axle ]
25 Nm + 90° Rear axle stabiliser mounting (Use new screw(s). ) [at the axle support ]
40 Nm + 90° Rear axle stabiliser support at stabiliser (Use new screw(s) and nut(s). )
40 Nm + 90° Rear axle stabiliser support at axle control arm (Use new screw(s). )
Wheels/tires :
4 Nm Tyre pressure sensor(s)
Consumables
Filling quantities and specifications :
6,20 Engine oil with filter
VW 504 00 Engine oil specification [Longlife ]
G 052 516 A2 Automatic gearbox oil specification (Original oil ) [Multitronic 0AW ]
1,10 Front axle differential oil [Multitronic 0AW ]
G 052 190 A2 Front axle oil specification (Original oil ) [Multitronic 0AW ]
G 004 000 M2 Power steering oil specification (Original oil )
G 055 532 A2 Manual gearbox oil specification (Original oil ) [Gearbox 0B2 ]
4,80 Manual gearbox oil [Gearbox 0B2 ]
Lighting
Internal light sources :
W5W 12V 5W W2,1x9,5d Glove compartment light
W5W 12V 5W W2,1x9,5d Reading light
LED Footwell light (Original part )
W5W 12V 5W W2,1x9,5d Entry light
W5W 12V 5W W2,1x9,5d Boot light
W5W 12V 5W W2,1x9,5d Door safety light
W5W 12V 5W W2,1x9,5d Door light
C5W 12V 5W SV8,5 (11x35) Interior light
Rear light sources :
LED Auxiliary stop light (Original part )
LED License plate light (Original part ) [from 2013 ]
LED Rear fog lamp (Original part ) [from 2013, Tail light with light-emitting diodes ]
W16W 12V 16W W2,1x9,5d Back-up lamp
LED Stop lamp (Original part ) [Tail light with light-emitting diodes ]
LED Tail light (Original part ) [Tail light with light-emitting diodes ]
LED Rear direction indicator (Original part ) [from 2013, Tail light with light-emitting diodes ]
Front light sources :
LED Side direction indicator
PWY24W 12V 24W WP3.3x14.5-4 Front direction indicator (Original part ) [from 2013 ]
H8 12V 35W PGJ19-1 Fog lamps [from 2013 ]
LED Parking light [with bi-xenon ]
H7 12V 55W PX26d Cornering light [from 2013, with bi-xenon ]
D3S 85V 35W PK32d-5 High beam [with bi-xenon ]
D3S 85V 35W PK32d-5 Low beam [with bi-xenon ]
Change intervals
For service data :
every 30.000 km / 2 years Interior filter change interval
every 60.000 km Automatic gearbox oil change interval [Multitronic 0AW ]
after 3 years for the first time, then every 2 years Brake fluid change interval
every 90.000 km / 6 years Spark plug change interval
every 90.000 km Air filter change interval
Tüüp:
Estate ► 08-12
KBA: 0588 APO
Mootor:
3.2 (CALA)
Võimsus:
195 KW / 265 HP
Maht:
3197 cm Petrol
Veoskeem:
Esivedu ►
Kütus:
Bensiin
Spetsifikatsioonid:
6,20 litres
Engine oil with filter
VW 504 00
Engine oil specification
4,80 litres
Manual gearbox oil
G 055 532 A2
Manual gearbox oil specification
D3S 85V 35W PK32d-5
Low beam
D3S 85V 35W PK32d-5
High beam
G 052 516 A2
Automatic gearbox oil specification
1-4-3-6-2-5
Firing sequence
1,10 litres
Front axle differential oil
G 052 190 A2
Front axle oil specification
0,00 bar
Front tyre pressure
0,00 bar
Rear tyre pressure
LED
Parking light
LED
Stop lamp
G 004 000 M2
Power steering oil specification
every 90.000 km / 6 years
Spark plug change interval
600 - 800 1/min
Idling speed with manual gearbox
-1°20'+0°25'-0°25'
Camber rear
2808 mm
Wheel base
Lisateave (260) ►
Sidur, ehitusosad
Teljeajam
Lisaülekanne

car-mod.com